concreting in Mildura

Yes, replacing cracked and lifting concrete is a big part of our Mildura work, because so many established homes still carry settlement-era slabs and driveways. We break out and remove the old concrete, reassess and recompact the base, and repour to the correct thickness with steel mesh and proper control joints. Removal and disposal do add to the cost compared with a fresh pour on clear ground, so we itemise that in your quote. Once we have seen the area we can tell you whether a full replacement or a repair is the sensible call.

Timing and curing do the heavy lifting here. On hot days we pour early in the morning before the peak heat and wind, and we apply an evaporative retarder to slow surface moisture loss while we finish. After finishing we keep the slab continuously cured, using damp hessian or a curing compound over several days so the concrete gains strength properly. We also set out control joints at the right spacing, which guide where any shrinkage cracking appears rather than leaving it to chance across the slab.

It can, so it is worth flagging. Salty, damp ground in the older irrigation blocks and floodplain can attack the cement paste and speed up corrosion of the steel over time. Where a site test or the conditions point to that risk, we use a higher-grade, more durable mix suited to the exposure, lay a continuous damp-proof membrane under the slab and make sure the reinforcement has adequate cover from the ground. The right approach depends on your specific block, which is why we assess conditions on site before recommending a mix.

As a rough guide, a standard new plain concrete driveway on clear, easily accessed ground with straightforward base preparation tends to sit around the 70 to 100 dollars per square metre mark. That figure moves once you factor in removing old concrete, difficult access, extra thickness for heavier vehicles, decorative finishes or salinity detailing in damp ground. Because of that, we never quote a real job on a per-metre rule of thumb. Steve comes out, measures up and gives you a fixed, itemised price for your exact scope.

For a house slab or a structural footing we recommend it, because Mallee ground varies from lot to lot. Much of Mildura sits on deep sandy calcareous soil that is often stable, but reactive texture-contrast clay or uncontrolled fill can turn up on the same street, and that changes how a footing should be designed. A site classification under AS 2870 confirms what your block actually is rather than us guessing from the district. For a simple path or a shed slab it is usually less critical, and we will tell you honestly what your job needs.

Yes on both. We are fully insured, including 20 million dollars of public liability, so you are covered while we are on your property. Every quote is fixed and itemised, worked out on site so you can see exactly what is included before any work starts. If anything about the scope changes once we are underway, we agree the variation with you in writing rather than springing a surprise at the end. That way there are no unexpected numbers when the job is done.